Hyundai, Kia recall over 500,000 vehicles due to leaks that can cause engine fires

Volvo recalling 2.1M vehicles worldwide

Volvo Cars says it is recalling nearly 2.1 million vehicles worldwide as a preventive measure after the company discovered that a steel wire connected to the front seat belts can be weakened.

DETROIT - Korean automakers Hyundai and Kia are recalling over 500,000 vehicles in the U.S. and Canada to fix a brake fluid leak that could cause engine fires.

The recalls cover more than 440,000 Kia Optima midsize sedans from 2013 through 2015 and Kia Sorento SUVs from 2014 and 2015. Also covered are 203,000 Hyundai Santa Fe SUVs from 2013 to 2015.

The affiliated automakers say brake fluid can leak inside a hydraulic control unit for the anti-lock brakes, possibly causing an electrical short that can lead to fires.

Kia's recall will start Oct. 15, while Hyundai's will start Oct. 23. Dealers for both companies will inspect the control units for leaks and replace them if needed at no cost to owners.

In company documents posted Thursday by U.S. safety regulators, Hyundai said it had 15 reports of engine fires caused by the fluid leaks, while Kia said it had eight. Hyundai said it's not aware of any injuries, and Kia said it had none.

Hyundai said in a statement that there's no need to park vehicles outdoors before the problem is fixed, but if the anti-lock brake warning light comes on, owners should not drive their vehicles and should contact a dealer. They also should disconnect the 12-volt battery by removing the positive cable, the company said.

Hyundai documents said the company received its first complaint about an engine fire in a 2014 Santa Fe in April of 2018, and it started an investigation. Kia began investigating after getting a complaint of a melted control unit in a 2015 Sorento last February.

The recalls are the latest in a series of engine fire problems that have plagued the two automakers and have touched off investigations by the U.S. National Highway Traffic Safety Administration.

In February, Hyundai recalled nearly 430,000 small cars for a similar but apparently unrelated problem. The company said water can get into the antilock brake computer, cause an electrical short and possibly an engine fire. That recall covered certain 2006 through 2011 Elantra and 2007 through 2011 Elantra Touring vehicles.

The company said the electrical short could cause a fire even when the cars are turned off.

Hyundai said the latest recall is not related to the previous recalls or the U.S. investigations. The company said it monitors safety concerns, including non-collision fires “and acts swiftly to recall any vehicles with safety related defects.”

In April of 2019, NHTSA opened two new investigations into fires involving Hyundai and Kia vehicles after getting complaints of more than 3,100 fires and 103 injuries.

The agency granted a petition seeking the investigations by the nonprofit Center for Auto Safety, a consumer advocacy group.

The investigations, one for Hyundai and the other for Kia, cover non-crash fires in almost 3 million vehicles from the affiliated automakers. The investigations include the 2011 through 2014 Hyundai Sonata and Santa Fe, the 2011 through 2014 Kia Optima and Sorento, and the 2010 through 2015 Kia Soul. The complaints came from consumers and from data provided by both automakers.

NHTSA had previously said it would incorporate the noncrash fires into a 2017 investigation that examined recalls of Hyundai and Kia vehicles for engine failures. It opened the new probes “based on the agency’s analysis of information received from multiple manufacturers, consumer complaints and other sources.”

Engine failure and fire problems with Hyundais and Kias have affected more than 6 million vehicles since 2015, according to NHTSA documents.

News Consumer Recalls Transportation Consumer